Author Topic: should both wires of my dynamo be grounded?  (Read 2681 times)

Offline snowbeard

  • American Citizen in Lisbon, Portugal
  • A's Good Friend
  • ***
  • Join Date: Aug 2007
  • Posts: 246
  • Karma: 1
should both wires of my dynamo be grounded?
« on: 03.09. 2007 04:52 »
I tried to test my wiring to see if the carb fire shorted any of it out, and I found that both the yellow and green wires are "connected", i.e when I test the yellow at the regulator for continuity it's good, but so it is also good at the green on the regulator when testing it to the yellow at the generator.

in addition, they both ground to the frame as continuous from the generator.

is this normal? or has my generator shorted out...

thanks!
__________________
\'57 BSA A-10 Spitfire Scrambler
Spitfire Starting Video
\1960 Super Rocket (basket)
\1981 Suzi GS650
\1988 BMW K100LT in Lisbon!!

=

Offline fido

  • Ferdinandovac, Croatia
  • Resident Legend
  • *****
  • Join Date: Aug 2006
  • Posts: 712
  • Karma: 9
Re: should both wires of my dynamo be grounded?
« Reply #1 on: 03.09. 2007 07:27 »
The resistance figures for the armature and field windings are very low so they could well appear as short circuits, depending on what equipment you are using to test them. The dynamo is wired with one field coil and one brush wire connected to its casing inside, the other 2 connections being the F (field) and D (dynamo i.e. brush) which go to the regulator via green and yellow wires respectively. I suggest you rig up a 12 volt bulb eg a car turn indicator bulb to test the dynamo. To do this you take off the wires to the dynamo, join it's F and D terminals together with a short wire link and connect this to one bulb contact. Connect the other bulb wire to the bike ground and start the engine but don't rev too high or the bulb will blow.

Offline LJ.

  • Peterborough UK.
  • Wise & Enlightened
  • *
  • Join Date: Jun 2006
  • Posts: 1403
  • Karma: 15
  • The Red A10!
    • LJ's Website!
Re: should both wires of my dynamo be grounded?
« Reply #2 on: 03.09. 2007 08:22 »
Here is a handy little tool most of us could make for testing dynamos at some time or other...
As already been said... plug the two plugs into the F & D (doesn't matter which way round) and crocodile clip to earth somewhere and then start motor. A good dynamo should output around 17 volts so don't rev too hard or the 12volt bulb will blow. This then determines that your dynamo is working.
Ride Safely Lads! LJ.
**********************
1940 BSA M20 500cc Girder/Rigid- (SOLD)
1947 BSA M21 600cc Girder/Rigid-Green
1949 BSA A7   500cc Girder/Plunger Star Twin-(SOLD)
1953 BSA B33  500cc Teles/Plunger-Maroon
1961 BSA A10  650cc Golden Flash-Blue
1961 BSA A10  650cc Golden Flash-Red

Offline snowbeard

  • American Citizen in Lisbon, Portugal
  • A's Good Friend
  • ***
  • Join Date: Aug 2007
  • Posts: 246
  • Karma: 1
Re: should both wires of my dynamo be grounded?
« Reply #3 on: 03.09. 2007 16:56 »
I was just using a decent multimeter on buzz for connection, at the lowest setting. I'm glad to hear it doesn't mean certain death for my dyna, Thanks again!!

is there a problem with running the bike without a battery tho?  Does it require a battery to properly dissapate the generated energy?  will something overheat?

thanks again
__________________
\'57 BSA A-10 Spitfire Scrambler
Spitfire Starting Video
\1960 Super Rocket (basket)
\1981 Suzi GS650
\1988 BMW K100LT in Lisbon!!

=

Offline fido

  • Ferdinandovac, Croatia
  • Resident Legend
  • *****
  • Join Date: Aug 2006
  • Posts: 712
  • Karma: 9
Re: should both wires of my dynamo be grounded?
« Reply #4 on: 03.09. 2007 19:18 »
If you were going to do much riding without a battery it would be a good idea to remove the dynamo chain. It might not cause any damage to the dynamo but it is better to be safe than sorry.

Offline snowbeard

  • American Citizen in Lisbon, Portugal
  • A's Good Friend
  • ***
  • Join Date: Aug 2007
  • Posts: 246
  • Karma: 1
Re: should both wires of my dynamo be grounded?
« Reply #5 on: 03.09. 2007 22:15 »
so would that include removing the cover on the right side of the cranks?  just trying to gauge the options, just buy a battery now or disconnect...

thanks a ton!!
__________________
\'57 BSA A-10 Spitfire Scrambler
Spitfire Starting Video
\1960 Super Rocket (basket)
\1981 Suzi GS650
\1988 BMW K100LT in Lisbon!!

=

Offline dpaddock

  • NC, USA
  • Valued Contributor
  • ****
  • Join Date: Jul 2006
  • Posts: 429
  • Karma: 5
Re: should both wires of my dynamo be grounded?
« Reply #6 on: 07.09. 2007 17:01 »
You may safely ride without a battery as long as your lights are always ON. Take away the battery and insulate the hot lead to prevent it from grounding.
David
'57 Spitfire


Offline snowbeard

  • American Citizen in Lisbon, Portugal
  • A's Good Friend
  • ***
  • Join Date: Aug 2007
  • Posts: 246
  • Karma: 1
Re: should both wires of my dynamo be grounded?
« Reply #7 on: 07.09. 2007 17:10 »
thanks again!  ;) 

So I disconnected the leads from the generator,  and separated the fused wires above the carbs (this bike has experienced a carb fire)  so if my light works (!) with it all connected and the hot battery lead insulated, it should be alright?

would running it with the leads simply disconnected from the gen hurt it? (I only got about 200 ft  *whistle* )  I'm still only testing it gingerly to see if it likes to move anymore.
__________________
\'57 BSA A-10 Spitfire Scrambler
Spitfire Starting Video
\1960 Super Rocket (basket)
\1981 Suzi GS650
\1988 BMW K100LT in Lisbon!!

=

Offline dpaddock

  • NC, USA
  • Valued Contributor
  • ****
  • Join Date: Jul 2006
  • Posts: 429
  • Karma: 5
Re: should both wires of my dynamo be grounded?
« Reply #8 on: 07.09. 2007 17:55 »
You may safely ride with the generator leads disconnected.
David
'57 Spitfire


Offline snowbeard

  • American Citizen in Lisbon, Portugal
  • A's Good Friend
  • ***
  • Join Date: Aug 2007
  • Posts: 246
  • Karma: 1
Re: should both wires of my dynamo be grounded?
« Reply #9 on: 09.09. 2007 19:10 »
great!  that's the plan for now, while I get the rest of finding a battery, etc, sorted out.  thanks again!
__________________
\'57 BSA A-10 Spitfire Scrambler
Spitfire Starting Video
\1960 Super Rocket (basket)
\1981 Suzi GS650
\1988 BMW K100LT in Lisbon!!

=